travis' brain dump

Ok, so this was on heck of a project, lol. Ordered up the kit from Sam’s Club (thanks to my parents for letting me use their Sam’s card) for about $1400 shipped. We recieved the boxes, all 5 of them (4 plus the slide) about 4 days after ordering, I was pretty amazed. Here’s the outline review of the process. I wish I’d had more time in single days to dedicate to the project, but overall it didn’t take too terribly long. The first couple of days were hard to work on the project as I only had a couple hours after work.

Day 1 (2-3 hours work):
Unpack the boxes, review all the parts, etc.

[singlepic id=107 w=320 h=240 float=]

Amanda, supervising the unpacking of the parts.

[singlepic id=108 w=320 h=240 float=]

The piles growing in the back yard staging area.

[singlepic id=109 w=320 h=240 float=]

That’s a whole lot of parts!

Day 2 (1-2 hours work):
Let the assembly begin!

[singlepic id=110 w=320 h=240 float=]

A good chunk of Day 2 was spent not only getting the framework together but leveling the dang thing. Nothing says awesome like having to dig into the ground in odd places to shave off some land to get the main playhouse level.

Day 3 (3-4 hours work):
Finally, some visual progress!

[singlepic id=111 w=320 h=240 float=]

[singlepic id=112 w=320 h=240 float=]

[singlepic id=113 w=320 h=240 float=]

While I didn’t get quite as far as I had wanted to this day, at least the floor, the picnic table and all the primary supports were in place. The framework was also anchored into the ground at this point.

Day 4 (4-5 hours work):
This was a Saturday. While I’d hoped to get more work in today, it was cold in the morning then a busted cordless drill set me back an hour or so. Had to go get another one from Sears. Bummer.

[singlepic id=114 w=320 h=240 float=]

[singlepic id=115 w=320 h=240 float=]

I was hoping for a little more done today, at least get the slide and the steps up, but alas, it wasn’t in the cards. Kiddos will have to wait til Day 5 and me skipping a few steps to get the slide in so they have something to play on while I finish this thing. lol

Day 5 (4-5 hours work):
Much more progress today!

[singlepic id=116 w=320 h=240 float=]

Coming along nicely, next stop, the roof!

[singlepic id=117 w=320 h=240 float=]

Finally a roof! Assembly of this wasn’t too hard at all. Just more time consuming due to the smaller parts being assembled all over.

A lot got done today visually, but it really wasn’t much more work than Day 4. Still, it was finally coming together and looking like something!

Day 6 (5-6 hours work):
Finally almost there! Major progress visually, despite the fact it only took a few hours to get the monkey bars and the swings operational.

[singlepic id=118 w=320 h=240 float=]

Day 7 (1 hour work): FINISHED!

[singlepic id=119 w=320 h=240 float=]

[singlepic id=120 w=320 h=240 float=]

All in all it wasn’t a bad project. My only complaints were some of the upper portions (where the use of smaller parts is more common) didn’t quite fit correctly. Not much modification was needed but you needed to know how to spot some of upcoming problems of placing a piece in a location that you might have to move it from later. Accuracy of the instructions to the parts, I’d give it a 7 out of 10. Nothing structurally problematic though, just mostly cosmetic. The only major issue I had with this was the lack of enough 3″ lag screws and 3/4″ truss bolts/barrell nuts and lock nuts. Those things were the bane of my existance. Nothing a trip to Home Depot didn’t fix, however.

I most certainly wouldn’t say this thing is sturdy enough for adults to play on, but the kiddos… you could load up about 5-6 on there without a single hint of strain. I for one am glad to be done with it. The last day just bugged me getting the final little pieces finished and all checked out. Can’t complain too much though as it sure beat buying something similar from Backyard Adventures or Rainbow for twice as much. Just an FYI, this set is made by a company called Backyard Liesure Holdings which just so happens to be the same company that creates the following playsets:

– Create-N-Adventure™
– Adventure Playsets™
– Backyard Adventures™
– Leisure Time Products™
– Backyard Builders™
– Politron™

Pretty interesting. So all in all I got the same product (for the most part) as Backyard Adventures for about half the cost, although I had to put in the ~24-25 hours of work. Still worth it in the end to see the kids having a blast playing on it. If you’re looking for an affordable, large scale playset. I can’t say I’d warn you away. Just make sure you take your time, read the instructions and assemble the parts properly. 🙂

Now comes the fun part of destroying the old swingset and playhouse… muhaha!